Tesla Model X Battery Replacement Cost


Don’t Supercharge Unless It’s Necessary

Tesla Model X (2016 – 2021) – New Battery Install

While Tesla’s supercharger network is an impressive feature that allows you to take your battery charge from 10% to 80% in approximately 35 minutes, using it very often may have a negative effect on your battery. Fast charging rates lead to faster wear of batteries, but that’s not to mean you should avoid the feature entirely because it is super useful.

How To Check Tesla Batterys Degradation

  • Charge the cars battery to 100 percent capacity.
  • Turn on the vehicle. Find the cars estimated range. You can locate this on Model S and Model X in the bottom left corner of the instrument cluster.
  • Divide that by the original battery range and multiply by 100 to determine how much capacity is available.

Tesla Model S Battery Replacementhow Much Does It Cost

While battery replacement reports from stateside owners of the Model S outside of warranty are few and far between, we have found a few cases where a full battery replacement visit has cost up to $20,000. That sounds pretty high, but the breakdown in price shows that the Model S battery itself costs somewhere in the realm of$12,000-$15,000.

Additional replacement parts, such as connectors and wiring, are sometimes needed, most of those being in the $20-$200 range. Finally, depending on whether there is damage to be repaired or a complication in the replacement, battery replacement is reportedly taking anywhere from 3 to 13 hours. As labor costs at the Tesla Service center have been reported around $175-$200 per hour, thats an additional $525-$2,600. It sounds excessive until you remember that all these personnel are handing a high voltage system, and the overhead for their insurance and facilities compliance is pretty steep.

Bottom line: the cheapest estimate for an out-of-pocket, uncomplicated battery replacement on the Model S should cost about $12,000-$13,000 for the battery, $100-200 for miscellaneous parts, and $500-600 for labor. This puts the grand total at around $13,000-$14,000 for a full Model S battery replacement.

Recommended Reading: Electric Car Charging Stations New Hampshire

Final Word Tesla Battery Replacement Cost

A standard Tesla battery is designed to outlast the vehicle itself. According to Tesla, you can expect a Tesla battery to last 300,000 to 500,000 miles or longer, which means most Tesla drivers never need to worry about replacement.

However, if your battery has failed for various reasons, then you may need to replace it.

It costs $10,000 to $25,000 to replace a Tesla battery, depending on the battery type and size.

Contact Tesla today to determine how much your Tesla battery replacement could cost.

Recent Articles

Tesla Battery Replacement Cost

Tesla Battery Replacement Cost Unique Tesla Increases Model S and Model ...

It is common for car batteries to start having low performance after extended use. In a bid to have a smooth ride, you would need a good battery replacement that would effectively power the cars components.

For folks with Tesla cars, it would be best to learn about the tesla battery price. Such action would give you a clue when making a budget for your vehicle. However, the cost of Tesla battery replacements varies, depending on the car model. Nevertheless, below is an estimated cost of Tesla batteries.

Tesla Models

Don’t Miss: Buy Used Tesla Model S

How Often Does A Tesla Battery Need To Be Replaced

Youll need to replace the battery pack of your new Tesla after its usable capacity falls under 70% of its capacity. This also means the driving range falls to that same degree.

Once the battery drops below these levels, you need to take your car to a Tesla Service Center to proceed with the replacement. They wont fix the damaged battery pack but instead replace it with a new or refurbished one. The damaged one is returned to the factory for repair.

The Lowdown On Replacing A Tesla Model 3 Battery

Recurrent reports that replacing the battery of a Tesla Model 3 costs about $15,800. That works out to around $180 per kWh, more than the average cost of replacing a Nissan Leaf battery. Compared to hybrids and plug-in hybrids, like the Hyundai Ioniq, the cost per kWh of power is actually fairly competitive for the Model 3. However, because of the sheer size of the battery pack overall with potentially ten times the kWh count, if not more that pushes the Tesla’s total price up significantly, too. EV battery technology is getting better, more efficient, and cheaper Bloomberg reports that by 2030, the cost is expected to drop to $100/kWh and possibly as low as $58/kWh. However, new supply chain problems affecting lithium and other elements used in batteries could pause the downward price trend.

The Tesla warranty only covers malfunctions or damages caused by fabrication. If the battery is damaged due to collisions, exposure to fire, water, unauthorized services, improper maintenance, earthquake, windstorm, off-road driving, and several other events, the owner will face the cost. Many drivers who find themselves facing an EV battery replacement that isn’t covered by the warranty are choosing alternative methods which can cut costs dramatically.

Also Check: How Are Tesla Batteries Made

Tesla Owner Blows Up His Model S With Dynamite Over $22000 Battery Replacement

A Tesla Model S owner in Finland decided to blow up his electric car with dynamite after it needed a battery replacement, which Tesla said was going to cost $22,000.

Theres not a lot of information about how much an electric car, or especially Tesla vehicle, battery replacement costs.

Its a hard question to answer since the vast majority of Tesla battery replacements have been done under warranty.

Early on, Tesla offered eight-year unlimited mileage powertrain warranties for Model S and Model X.

With Model S production starting in 2012 and higher volumes not coming until 2014, only recently have those vehicles started to come off their powertrain warranty. We have seen quotes from Tesla for battery pack replacements between $20,000 and $30,000. Thats a lot of money, but the good news is that Teslas battery packs have been known to last a long time.

I have a Tesla Model X that had a battery pack last for more than 300,000 miles.

However, even if the problem is not necessarily battery degradation, the battery packs simply fail sometimes, and its expensive to replace those early packs.

We recently reported on a case where a Model S owner was told by Tesla that he needed a $22,500 battery replacement.

That wasnt really an option since its basically equivalent to the value of the vehicle.

But Katainen decided to go a different way.

That sounds like a reasonable solution to an expensive battery replacement.

How Many Years Do Tesla Batteries Last

Tesla battery degradation and replacement after 400,000 miles

How Many Years Do Tesla Batteries Last?

This is a question that we get a lot at our Tesla dealership. And its a valid question, because when youre making a big purchase like a Tesla, you want to know that its going to last.

The answer is that Tesla batteries are designed to last for either 22 or 37 years, depending on which model you purchase. The 22-year battery is standard on all models except the Model S P100D, which comes with the 37-year battery.

So, why the difference in battery life? It all has to do with the way that the batteries are used. The 22-year battery is designed for daily use, while the 37-year battery is designed for occasional use.

If youre planning on using your Tesla for long-distance travel or for other occasional uses, then the 37-year battery is the way to go. But if youre planning on using your Tesla for your daily commute, then the 22-year battery will be just fine.

Either way, you can rest assured that your Tesla will last for many years to come.

An additional, In the United States, the average life expectancy is about 78 years. However, this number will be different for different people based on a variety of factors, including where they live, their lifestyle, their genes, and their access to healthcare. For example, someone who lives in a rural area with poor access to healthcare is likely to have a shorter life expectancy than someone who lives in an urban area with good access to healthcare.

Read Also: Tesla Model Y Long Range Hp

Battery Monitoring To Avoid Replacement

It should not be a surprise that treating your battery nicely can expand its life and delay replacement. Here are some tips on how to give your battery the TLC it needs.

  • Avoid extreme high or low battery levels.
  • Limit DC fast charging to special occasions.
  • Small, frequent charges are better than large, infrequent charges.
  • Get your battery to room temperature before charging when possible. Usually this is accomplished by your vehicle automatically once plugged in.
  • Park in the shade during warm months to keep your battery cooler.
  • A/C and heat use a lot of energy so consider preheating your car while itâs plugged in or using seat warmers.
  • Accelerate slowly to increase range.
  • Avoid excessive highway speeds.
  • Check out your manuals battery maintenance tips.
  • Swap your tires for more efficient tires seasonally appropriate.

Are you an EV owner? Join the Recurrent EV community for free personalized reports on your vehicle. Not only do you get reports that offer insights into how well your EV is doing, but you contribute to a fast growing community of EV drivers who want to help others benefit from EVs, too! â

How Tesla Battery Replacement Works

A Tesla has multiple battery modules within a battery pack. Thats why Tesla battery replacement is different than ordinary vehicle battery replacement.

An ordinary, gas-powered vehicle has a single battery . This battery starts the car and powers electrical components within the vehicle. Because the car mostly runs on gas, the car doesnt need a large battery.

A Tesla works differently. A Tesla is completely electric, which means you need more battery power.

If you have a problem with one battery module in your Tesla, then its a serious issue. Voltages need to be similar across all battery modules. Otherwise, your vehicle may struggle to run.

When your Tesla battery module has a problem, you bring it to Tesla and they replace the entire battery pack not just a single module. They will install a new or remanufactured battery pack, then send the old battery pack to their facilities for repair and refurbishment. Then, your old battery pack could be manufactured into another Tesla that also needs replacement.

Recommended Reading: How Long Do Electric Car Batteries Take To Charge

Current Cost Of Battery Pack Replacement

Tesla’s battery packs are effectively a RAID design. 70+ individual cells in parallel, each fused individually.If one cell shorts, the link pops, and the pack goes on, having lost ~1.5%.As long as you can replace the pack level bits like the contactors and BMS separately, you should never have to replace the pack for wear/degradation.

Replying to @GfilcheModel 3 drive unit & body is designed like a commercial truck for a million mile life. Current battery modules should last 300k to 500k miles . Replacing modules will only cost $5k to $7k.

Moderator, Model 3, Tesla Energy Forums


How Much Does A Tesla Model 3 Battery Replacement Cost

Tesla slashes price of Model X 60D to 75D battery software upgrade by ...

Weve seen at least one service receipt that puts a Model 3 battery replacement at $13,500 for just the battery pack . With battery sizes ranging from 50kWh to 82 kWh, current battery price estimates put new Model 3 batteries closer to $7000-$11,000, still lower than the $13,500 on our example invoice.

Why is this nowhere near the $5,000-$7,000 quoted by Musk in 2019 ? Well, he clarified that the $5,000-$7,000 was per module, not per battery pack. The battery pack on the Model 3 is made up of 4 modules, so the estimated price for a pack replacement is a whopping $20,000-$28,000. Makes $13,500 sound pretty good, doesnt it?

As Tesla ramps up production of the Model 3 and constantly works to improve their battery design, its quite possible that the prices will fall dramatically in the next few years. For now, our lowest out-of-pocket cost estimate for uncomplicated battery replacement on a Model 3 would is approximately $13,000 .

Don’t Miss: Who Made The Car Tesla

Chevy Bolt Battery Replacement Cost

As you may be aware, currently all Chevy Bolt batteries are set to be replaced under a recall for a manufacturing defect in their batteries. Perhaps it can help you get a sense of when the pre-recall Chevy Bolt batteries may no longer have met your needs and may need a battery replacement. Below are some examples of Chevy battery replacements costs prior to the recall.

  • According to a post on chevybolt.org, a dealership quoted a Chevy Bolt owner in November 2018 $16,250 for a battery replacement, with $870 for labor. Given that Chevy Bolt batteries are rated at 60 kWh, that equates to approximately $271/kWh, about 68% higher than the 2019 average price.
  • According to Chevrolet themselves, in 2017 they reported that the price of a battery pack for a Chevy Bolt was $262/kWh.
  • According to a 2020 Greencars, a 66 kWh Chevrolet Bolt battery costs ~$16,000, or $250/kWh.

How Tesla Replace Batteries

There are numerous reasons why a Tesla’s battery pack will die. It could be a voltage regulator issue, a fuse issue, or several other minor reasons. However, if the problem is within one battery module, the entire battery pack is affected.

That’s because the voltages across all battery modules must be similar. Even if just one module displays a value far different from all the others, it could cause the complete pack to fail.

When that happens, bring your car to Tesla, and they’ll fix it. However, they won’t replace just one module. Instead, they install a completely new or remanufactured battery pack and then send the old one to their battery plants for repair and refurbish. Once the old battery pack is fixed and checked, they return that pack into the system, ready to be installed in another car that needs a battery swap.

Related: The Most Common Questions People Ask About Electric Cars

They don’t replace battery modules in Tesla shops because they want to ensure that the battery they install in your car has 100% health. For this reason, they have their professionals go over it in their plants instead of replacing just one part of the battery, putting it back in your car, and then calling it a day.

While this is an excellent process to ensure that your car returns to a near new condition when they service it, it’s also expensive and might be out of reach for some owners. This is where third-party repair shops come in.

You May Like: 2020 Tesla Model S Price

It Costs $10000 To $25000 To Replace A Tesla Battery

When you buy a Tesla, nearly half of your purchase goes towards the battery. Tesla batteries are expensive, and each Tesla vehicle uses multiple battery modules.

According to Elon Musk, it costs $5,000 to $7,000 to replace a battery module in a Tesla. Each Tesla vehicle uses four to five battery modules, which means a complete Tesla battery replacement should cost $20,000 to $35,000.

Today, however, you could pay less or more than that amount to replace a Tesla battery.

According to a report by Current Automotive, which used a Tesla invoice as a source, it costs $16,550.67 to completely replace a 75kWh battery in a Tesla Model 3. That cost included $14,251.40 in parts and $2,299.27 in labor. The battery itself was priced at $13,500.

The price of batteries varies between models. You could pay $9,000 to $10,000 for a remanufactured battery pack, for example, or as much as $22,500 for a new battery pack.

Some Tesla drivers replace a damaged battery pack with a remanufactured one to save money. This replacement should cost $13,000 to $17,000. However, if you want to buy a completely new battery, then you could spend as much as $25,000, including parts and labor.

Driving Method And Conditions

Tesla Model X 12v Battery Replacement EASY PEASY HOW TO

Just like the traditional internal combustion engines, your car’s battery will be affected by how you drive. Generally, you might not make it to full range if you drive fast, and the battery will be depleted faster. Furthermore, the battery tends to use more power when driving in tough conditions like rainy or snowy weather.

To maximize the battery, ensure you’re driving at a safe speed, brake slowly, reduce the excess weight that is inside your car, and keep the tires fully inflated. Like any car, the way to take care of and maintain your Tesla, the longer the battery will last. However, no matter how well you take care of your car, there is a point where battery replacement will be needed.

Also Check: Childrens Electric Cars 24 Volt

Is The Tesla Battery Replacement Covered By A Warranty

After looking at the price for a Tesla battery replacement, you are likely trying to figure out how to save as much money as possible on this vital component. That leads you to wonder if you can have the replacement covered by the warranty.

Tesla currently offers an 8-year/150,000-mile battery warranty. Its void as soon as one of these milestones is met. While it has a warranty, the battery is only covered if there is a proven manufacturing defect. If the high voltage cable or a battery cell fails, Tesla will cover the cost of the parts and labor. You may also be able to get reimbursement for other related expenses, such as towing or a loaner vehicle.

This battery warranty does have some exceptions worth noting. If you drive a pre-2020 Model X or Model S, the battery warranty is or 8 years or unlimited miles. However, if the car contains a 40 kWh or 60 kWh pack, the warranty is 8-year/125,000-mile instead.

Theres also a clause with the warranty that covers the replacement if its due to degradation. The battery is covered by the warranty replacement if it has lost more than thirty percent of its factory capacity. The only exception to this rule is the first Tesla Roadster, but these original models are no longer covered by the warranty anyway at this point.

Share post:



More like this

Battery Replacement Cost For Tesla

How Much...

What Battery Company Does Tesla Use

Solarcity Faked...

How Long To Charge Electric Car Battery

Factors That...